VW Touran Climate Control problem.

[a.j.b...@talk21.com]

Hi there.

I have an 05 plate Touran (2.0 Tdi Sport). I have noticed,
particularly on long journeys, there appears to be less and less air
over time coming out of the vents.

It gets to a point where I have switched it out of "Auto" mode and set
the fan to FULL speed and both temps to 16 Degrees withour any
significant air flow dispite hearing the fan behind the dash trying to
blow the air without any noticable results ? (I don't feel it blowing
anywhere else.

When the car is then left with ignition off for a few mins it appears
to work again with LOTS of air coming out of the vents. Then over a
short time it then reverts back to its rather astmatic efforts.

Ocasionally turning teh AC compressor off and on again sometimes
resets it, as does setting teh temp to LO, but both of these are not a
guarantee to get it funtioning as it should.

It appears as if the main flow is being restricted by something over
time ? Dealer has looked at it and NO fault codes recorded !!

It has 1 month left on VAG warranty, so it's booked in for a longer
look !

Any thoughts as to what this problem could be ?

Thanks in advance.
Andy

[Mrcheerful]

when was the pollen filter last replaced?

[a.j.b...@talk21.com]

> when was the pollen filter last replaced?

It was probably done at last Service by VAG ? I have had the car from
new and always services when required.

I am unsure as to how this could be the cause of restricted aitflow
over time ?, which then goes away then car has rested for a while ?
But, I am open to suggestions ?

It feels as though some "Flap" is not fully letting the air through,
which sometimes the resets itself.

Where is the Pollen filter ? I can check to see if it looks nice and
clean ? ot has been correctly fitted ?

Any thoughts ?

Thanks,
Andy.

[Duncan Wood]

They do suffer from sticking flaps, if you pull the fault codes from the
aircon it should tell you.

http://forums.vwvortex.com/zerothread?id=339642

[Harry Bloomfield]

a.j.b...@talk21.com expressed precisely :

> Ocasionally turning teh AC compressor off and on again sometimes
> resets it, as does setting teh temp to LO, but both of these are not a
> guarantee to get it funtioning as it should.

I know nothing about the Touran, however...

Could the coil/fins of the unit be freezing up and blocking the flow?

There is supposed to be a sensor on the fins to sense the temperature
and turn the compressor off if they get too cold and start to ice up.
If that sensor has failed or giving a spurious reading...

That would fit in with your turning the a/c off, it defrosting and your
then getting airflow again. Is there a large pool of water appearing
under it, when you stop and after the air flow has dimished?

--
Regards,
Harry (M1BYT) (L)
http://www.ukradioamateur.co.uk

[Harry Bloomfield]

Harry Bloomfield brought next idea :

dimished = diminished = when the air flow problem has appeared during
the run.