Google Groups no longer supports new Usenet posts or subscriptions. Historical content remains viewable.
Dismiss

gas gauge/gas-miles remaining anomaly

3 views
Skip to first unread message

ted

unread,
Nov 13, 2005, 10:51:57 PM11/13/05
to
I have a 2002 330c. I had it tuned up just before I went on a trip from DC to Panama City Florida.
 
On the way back  whilst driving on I95 I exited to get gas. My gas gauge needle was just above the empty line(the empty line was visible) and the computer said I had 29 miles of gas left. The low fuel light was on.
 
As I hit the top of the exit ramp the car started to sputter and I barely made it to the station before the car died because I was out of gas. The needle was still just above empty and the computer said 28 miles of gas was left. If I had waited one more exit I was screwed.
 
After I filled the tank the computer said I had 415 miles of gas left and I got back to DC without a problem. From then on I never let the car get much below a 1/4 tank.
 
Is this kind of inaccuracy to be expected?
Could long drives where the vehicle speed is consistently 80mph cause this kind of problem?
Could there be a sensor malfunction?
 
Thanks
 
 

Malt_Hound

unread,
Nov 14, 2005, 9:47:32 AM11/14/05
to

Sounds like your sending unit is lying. Generally there is some error,
but it is found on the other side of empty (on both). Since both the
gas gauge and OBC rely on input from the gas tank sending unit to tell
it how much fuel remains that would explain why both were a bit
"optimistic". Know this now you could always just subtract ~30 miles
from the OBC's estimate or have the sender replaced. But then you'd
have to find out where empty is on that one too...

--
-Fred W

Jim

unread,
Nov 14, 2005, 11:02:50 AM11/14/05
to
The miles remaining is only an approximation based on the computer's knowledge of how much gasoline has been sent to the engine and the fuel level indicator's report of the gasoline remaining.  The gas gauge and the fuel level indicator are not precision instruments.  Nobody should wait until the low fuel light is on before stopping for gas.
Jim

Raybender

unread,
Nov 14, 2005, 2:56:47 PM11/14/05
to
As others have mentioned, this is most likely a sensor error. There are
two fuel level sensors (at least in my E36 - think it is the same for
you) in the tank - one for each side of the saddle bag. Both units are
supposed to read 250 ohms when full, and about 10 ohms when empty.
Problem is BMW is not very careful about calibrating them.

Since one or both of your sensors is reading high (saying more gas than
actually there) you can calibrate the sensors, if you wish. Did this
with mine, since I drive long stretches in CA and Nevada, and the last
thing I want is to run out of gas in the middle of nowhere. Procedure
is simple. Just place a 1/4 watt resistor in parallel with any sensor
that's reading high. Compute the resistance so that you will bring the
sensor unit to 250 ohms, or slightly less at a full tank. In my case it
took 2000 ohms across the passenger side unit - driver's side unit was
ok.

Now it's great. On a trip when gauge shows 1/2 tank, I'm down 8 gallons
+ - 1/4 gallon, or so. At only 1/4 tank, I'm down 12 gallons. So gauge
is essentially right on the money using 16 gallons as a full tank -
leaves me with the extra 0.4 gallons or so as a reserve. Now I just
mentally compute mpg on the first 8 gallons of gas, and estimate when
I'll need gas next without going below 14 gallons or so. Works like a
charm.

Frank

ted wrote:

> I have a 2002 330c. I had it tuned up just before I went on a trip
> from DC to Panama City Florida. On the way back whilst driving on I95
> I exited to get gas. My gas gauge needle was just above the empty
> line(the empty line was visible) and the computer said I had 29 miles
> of gas left. The low fuel light was on. As I hit the top of the exit
> ramp the car started to sputter and I barely made it to the station
> before the car died because I was out of gas. The needle was still
> just above empty and the computer said 28 miles of gas was left. If I
> had waited one more exit I was screwed. After I filled the tank the
> computer said I had 415 miles of gas left and I got back to DC without
> a problem. From then on I never let the car get much below a 1/4

> tank. Is this kind of inaccuracy to be expected?Could long drives


> where the vehicle speed is consistently 80mph cause this kind of

> problem?Could there be a sensor malfunction? Thanks

0 new messages